Chevrolet Cruze manuals

Chevrolet Cruze Repair Manual: Windshield Washer Pump Seal Replacement

Chevrolet Cruze Repair Manual / Body systems / Wipers and Washers / Windshield Washer Pump Seal Replacement

Removal Procedure

  1. Open the hood.
  2. Remove the windshield washer pump. Refer to Windshield Washer Pump Replacement
  3. Using a small flat-bladed tool, remove the washer pump terminal seal (1) from the washer solvent container (2).

Installation Procedure

  1. Position the washer pump terminal seal (1) to the washer solvent container (2), pressing in until fully seated.
  2. Install the windshield washer pump. Refer to Windshield Washer Pump Replacement
  3. Close the hood.

Air Inlet Grille Panel Replacement

Preliminary Procedure

Preliminary Procedure

Remove the wiper arms. Refer to Windshield Wiper Arm Replacement.

  1. Air Inlet Grille Panel Clip (Qty: 5)
  2. Air Inlet Grille Panel Assembly

Procedure

Remove hood rear weatherstrip.

Windshield Washer Pump Replacement
Removal Procedure Remove the front wheelhouse liner. Refer to Front Wheelhouse Liner Replacement. Disconnect the washer pump electrical connector (1). Disconnect the washer pump hose (2 ...

Windshield Wiper Arm Replacement
Windshield Washer Arm Finish Cap Tip Use a small flat-bladed tool to remove finish cap. Special Tools BO-6626 Wiper Arm Puller For equivalent regional tools, refer to Special Tools. ...

Other materials:

Heating and Air Conditioning System Description and Operation
Engine Coolant Engine coolant is the key element of the heating system. The thermostat controls engine operating coolant temperature. The thermostat also creates a restriction for the cooling system that promotes a positive coolant flow and helps prevent cavitation. Coolant enters the heater ...

Shock Absorber Disposal
Warning: Use the proper eye protection when drilling to prevent metal chips from causing physical injury. Clamp the strut in a vise horizontally with the rod ( 1) completely extended. Drill a hole in the strut at the center of the end cap (3) using a 5 mm (3/16 in) drill bit. Gas o ...

Cruise Control
For vehicles with cruise control: : Press to turn the cruise control system on and off. RES/+: Move the thumbwheel up to resume a previously set speed or to accelerate. SET/−: Move the thumbwheel down to set a speed or to make the vehicle decelerate. : Press to disengage cruise contro ...

© 2017-2021 Copyright www.crion.site