Chevrolet Cruze manuals

Chevrolet Cruze Repair Manual: Water Management Description and Operation

Chevrolet Cruze Repair Manual / Body hardware and trim / Exterior Trim / Water Management Description and Operation

Plenum Water Flow Direction and Cleaning

A large percentage of water will flow off the windshield area into the plenum chamber drain system and then down the outside on the plenum to the underside of the vehicle. To ensure that the plenum chamber water management system performs properly, the air inlet grille panel, plenum chamber, and drains must not be blocked with debris.

In the graphic below the gray arrows show the water flow direction in the plenum chamber and drains system.

Plenum Chamber and Drain Valve-Cleaning

Plenum Chamber and Drain Valve-Cleaning

The plenum chamber is located in front of the windshield and below the air inlet grille panel.

  1. Remove the air inlet grille panel. Refer to Air Inlet  Grille Panel Replacement.
  2. Clean the plenum chamber, drains and the air inlet grille panel of debris blockage.
  3. Flush the plenum chamber, drains and the air inlet grille panel with clean water.
  4. Install the air inlet grille panel. Refer to Air Inlet Grille Panel Replacement
Rear Compartment Lid Emblem/Nameplate Replacement (VCDi AT)
Rear Compartment Lid Emblem Assembly Caution: Refer to Exterior Trim Emblem Removal Caution in the Preface section. Procedure The part and surface should be 21°C (70°F) prior to installati ...

Floor Coverings and Headlinings
...

Other materials:

Wheel Alignment Measurement
Steering and vibration complaints are not always the result of improper alignment. One possible cause is wheel and tire imbalance. Another possibility is tire lead due to worn or improperly manufactured tires. Lead/pull is defined as follows: At a constant highway speed on a typical straight ...

Rear Side Door Window Adjustment
Warning: Refer to Glass and Sheet Metal Handling Warning in the Preface section. Warning: Refer to Express Window Down Warning in the Preface section. Preliminary Procedures Remove the rear side door trim. Refer to Rear Side  Door Trim Replacement. Remove the water deflector. ...

Front Fender Replacement
Preliminary Procedure Remove the front bumper fascia. Refer to Front  Bumper Fascia Replacement Remove front bumper fascia guide. Refer to Front Bumper Fascia Replacement Remove the wheelhouse liner. Refer to Front Wheelhouse Liner Replacement Remove the headlamp. Refer to H ...

© 2017-2021 Copyright www.crion.site