Chevrolet Cruze manuals

Chevrolet Cruze Repair Manual: Tracing Powder or Chalk Test

Clean the weatherstrips and the contact surfaces with cleaning solvent.

  1. Apply powder or chalk in an unbroken line to the contact surface of the weatherstrip surrounding the perimeter of the suspected areas.
  2. Close the panel completely without slamming the panel. Closing the panel completely presses the weatherstrip firmly against the mating surface.
  3. Inspect the applied line on the weatherstrip. The applied line is marred where contact is good. A corresponding imprint is on the mating surfaces.
  4. Gaps or irregularities in the powder or the chalk line on the mating surfaces indicate the areas with a poor seal.

Air Pressure Test

  1. Mask off  both the pressure relief valves.
  2. Close all the windows.
  3. Turn the vehicles ventilation fan to the on position, with the selector on high speed and in the defrost mode.
  4. Unlock and close the doors.
  5. Listen for escaping air along the door and the window seals with a stethoscope or a length of heater hose.

Soap Suds or Bubble Test

  1. Mask off the pressure  relief valves.
  2. Close all the windows and the doors.
  3. Turn the vehicles ventilation fan to the on position, with the selector on high speed and in the defrost mode.
  4. Unlock and close the doors
  5. Apply the soap solution to the potential leak areas.
  6. Look for bubbles revealing escaping air.
Air/Wind Noise
Special Tools CH-39570 Chassis Ear GE-41416 Ultrasonic Leak Detector Warning: Refer to Assistant Driving Warning in the Preface section. To analyze a reported windnoise condition, test drive ...

Exterior Windnoise
Warning: Refer to Assistant Driving Warning in the Preface section. Exterior windnoise is louder when the vehicle is driven with one or more windows down. Exterior windnoise occurs when air passes ...

Other materials:

Removal Procedure
Raise and support the vehicle. Refer to Lifting  and Jacking the Vehicle. Remove the tire and wheel. Refer to Tire and Wheel Removal and Installation. Note: DO NOT re-use the lower control arm bolts and nuts. Discard and use NEW only. Remove wheel speed sensor wiring harness ...

Where Are the Airbags?
The driver frontal airbag is in the center of the steering wheel. The front outboard passenger frontal airbag is in the passenger side instrument panel. The driver knee airbag is below the steering column. The front outboard passenger knee airbag is below the glove box. Driver Side Show ...

Passenger Airbag Status Indicator
The vehicle has a passenger sensing system. The instrument panel has a passenger airbag status indicator. United States Canada When the vehicle is started, the passenger airbag status indicator will light ON and OFF, or the symbol for on and off, for several seconds as a system check. If ...

© 2017-2021 Copyright www.crion.site