Chevrolet Cruze Repair Manual: Steering Wheel Inflatable Restraint Module Coil Replacement
Preliminary Procedure
- Remove the steering column upper trim cover. Refer to Steering Column Upper Trim Cover Replacement.
- Remove the steering column lower trim cover. Refer to Steering Column Lower Trim Cover Replacement.
- Remove the steering wheel. Refer to Steering Wheel Replacement.
Steering Wheel Inflatable Restraint Module Coil Screw Bolt (Qty: 4)
Caution: Refer to Fastener Caution in the Preface section.
Tighten 15 N·m (11 lb ft)
Steering Wheel Inflatable Restraint Module Coil Assembly
Procedure
Disconnect any electrical connectors as needed.
Tip
- Do not remove the centering tab from a new steering wheel inflatable restraint module coil until it has been installed or re-centering will be required.
- If re-centering of the steering wheel inflatable restraint module coil is needed then refer to Inflatable Restraint Steering Wheel Module Coil Centering.
Steering Wheel Inflatable Restraint Module Replacement
Removal Procedure
Warning: When carrying a live inflator module, make sure the bag opening
is pointed away from you. This minimizes the chance of injury
in the case of an accidental deployment. Ne ...
Inflatable Restraint Steering Wheel Module Coil Centering
Caution: The new SIR coil assembly will be centered. Improper
alignment of the SIR coil assembly may damage the unit, causing an
inflatable restraint malfunction.
Verify the following condi ...
Other materials:
Inflatable Restraint Module Handling and Scrapping
Special Tools
EL-38826 SIR Deployment Harness
EL-39401-B SIR Deployment Fixture
For equivalent regional tools, refer to Special Tools.
Live and Undeployed Inflator Module
Warning: Refer to SIR Inflator Module Handling and Storage Warning
in the Preface section.
Take special care when h ...
Front Lower Control Arm Bushing Replacement
Preliminary Procedure
Raise and support the vehicle. Refer to Lifting and Jacking the
Vehicle.
Remove the tire and wheel. Refer to Tire and Wheel Removal and
Installation.
Remove the lower control arm. Refer to Lower Control Arm Replacement.
Lower Control Arm Rear Bushing ...
Removal Procedure
Warning: Refer to Approved Equipment for Collision Repair Warning in the
Preface section.
Warning: Refer to Collision Sectioning Warning in the Preface section.
Warning: Refer to Glass and Sheet Metal Handling Warning in the Preface section.
Disable the SIR System. Refer to SIR Dis ...