Chevrolet Cruze manuals

Chevrolet Cruze Repair Manual: Steering Linkage Outer Tie Rod Replacement

Chevrolet Cruze Repair Manual / Steering / Power Steering / Steering Linkage Outer Tie Rod Replacement

Preliminary Procedure

Preliminary Procedure

Remove the tire and wheel assembly. Refer to Tire and Wheel Removal and Installation.

  1. Steering Linkage Tie Rod Nut

Caution: Refer to Fastener Caution in the Preface section.

Tighten 35 N·m (26 lb ft)

  1. Steering Linkage Inner Tie Rod Nut

Tighten 60 N·m (44 lb ft)

  1. Steering Linkage Outer Tie Rod

Procedure

  1. Use CH-161-B puller to separate the steering linkage outer tie   rod from the steering knuckle.
  2. Inspect the steering linkage inner tie rod for bent or damaged threads.
  3. Clean the tapered surface of the steering knuckle.
  4. Center the steering angle sensor. Refer to Steering Angle Sensor Centering
  5. Check and adjust wheel alignment. Refer to Wheel Alignment Measurement.

Special Tools

CH-161-B Puller

For equivalent regional tools, refer to Special Tools.

Power Steering Fluid Reservoir Replacement
Preliminary Procedure Remove as much power steering fluid from the remote power steering fluid reservoir as possible. Place drain pans under the vehicle as needed. Hose Clamp Pro ...

Steering Gear Boot Replacement
Special Tools CH-804 Drive Axle Seal Clamp Pliers Removal Procedure Remove the steering linkage outer tie rod. Refer to Steering Linkage Outer Tie Rod Replacement. Remove the steering lin ...

Other materials:

Emergency
With Automatic Crash Response, the built-in system can automatically connect to help in most crashes, even if help cannot be requested. Press to connect to an Emergency Advisor. GPS technology is used to identify the vehicle location and can provide critical information to emergency personne ...

Front Fender Front Lower Bracket Replacement
Preliminary Procedure Remove the front bumper fascia. Refer to Front   Bumper Fascia Replacement. Remove the headlamp. Refer to Headlamp Replacement Remove the front fender. Refer to Front Fender Replacement. Front Fender Bracket Bolt Caution: Refer to Fastener Caut ...

Seat Adjustment
WARNING You can lose control of the vehicle if you try to adjust a driver seat while the vehicle is moving. Adjust the driver seat only when the vehicle is not moving. To adjust a manual seat: 1. Pull the handle at the front of the seat. 2. Slide the seat to the desired position and release ...

© 2017-2021 Copyright www.crion.site