Chevrolet Cruze manuals

Chevrolet Cruze Repair Manual: Removal Procedure

Warning: Refer to Glass and Sheet Metal Handling Warning in the Preface section.

  1. Disable the SIR System. Refer to SIR  Disabling and Enabling.
  2. Disconnect the negative battery cable. Refer to Battery Negative Cable Disconnection and Connection.
  3. Remove the rear side door. Refer to Rear Side Door Replacement.
  4. Remove the rear side door outside handle. Refer to Rear Side Door Outside Handle Replacement.
  5. Remove the sealers and anti-corrosion materials from the repair area, as necessary. Refer to Anti-Corrosion Treatment and Repair.

  1. Grind the edges of the rear side door outer panel to separate the outer door panel from the door shell.

  1. Remove the rear side door outer door panel.
  2. Remove the sealers and anti-corrosion materials from the repair area, as necessary. Refer to Anti-Corrosion Treatment and Repair.
  3. Straighten the edges of the door shell.
Rear Side Door Outer Panel Replacement (MAG-Welding)
Special Tools BO-6396 Bonding Pliers BO-6392 Flanging Tool Kit For equivalent regional tools, refer to Special Tools. Note: According to different corrosion warranties, only the regional m ...

Installation Procedure
Align the rear side door outer panel. Verify the fit of the rear side door outer panel. Clamp the rear side door outer  panel into position. Pre-flanging the flange with BO-63 ...

Other materials:

Air Conditioning Evaporator Hose Assembly Replacement
Preliminary Procedures Recover the refrigerant. Refer to Refrigerant Recovery and Recharging. Remove the headlamp - right side. Refer to Headlamp Replacement. Loosen power steering fluid reservoir screw. Remove brake pipes from the dash lower extension panel. Remove engine mount. Ref ...

Charging System Light
The charging system light comes on briefly when the ignition is turned on, but the engine is not running, as a check to show the light is working. The light turns off when the engine is started. If it does not, have the vehicle serviced by your dealer. If the light stays on, or comes on whil ...

Removal Procedure
Warning: Refer to Approved Equipment for Collision Repair Warning in the Preface section. Warning: Refer to Glass and Sheet Metal Handling Warning in the Preface section. Disable the SIR System. Refer to SIR  Disabling and Enabling. Disconnect the negative battery cable. Refer to Bat ...

© 2017-2021 Copyright www.crion.site