Chevrolet Cruze manuals

Chevrolet Cruze Repair Manual: Removal Procedure

Warning: Refer to Approved Equipment for Collision Repair Warning in the Preface section.

  1. Disable the SIR System. Refer to SIR  Disabling and Enabling.
  2. Disconnect the negative battery cable. Refer to Battery Negative Cable Disconnection and Connection.
  3. Remove all related panels and components.
  4. Visually inspect the damage. Repair as much of the damage as possible.
  5. Remove the sealers and anti-corrosion materials from the repair area, as necessary. Refer to Anti-Corrosion Treatment and Repair.
  6. Locate and mark all factory welds.

  1. Drill all factory welds. Note the number and location of welds for installation of the service assembly.

  1. Remove the damaged roof rear header panel (1).
Roof Rear Header Panel Replacement (MIG-Brazing)
Note: According to different corrosion warranties, only the regional mandatory joining methods are allowed. ...

Installation Procedure
Clean and prepare the attaching surfaces for welding. Position the roof rear header panel (1) on the vehicle. Verify the fit of the panel. Clamp the roof rear header panel into positi ...

Other materials:

Installation Procedure
Install the following components on the drivetrain and front suspension frame if removed: The radiator support brackets. The stabilizer shaft--Refer to Stabilizer Shaft Replacement. The lower control arms--Refer to Lower Control Arm Replacement. The steering gear--Refer to Steering ...

Brake System Warning Light
The vehicle brake system consists of two hydraulic circuits. If one circuit is not working, the remaining circuit can still work to stop the vehicle. For normal braking performance, both circuits need to be working. If the warning light comes on, there is a brake problem. Have the brake system ...

Rear Side Door Trim Replacement
Rear Side Door Inside Handle Bolt Finish Cap Procedure Pull handle back to remove cap. Use suitable tool to unsnap. Rear Side Door Inside Handle Screw Caution: Refer to Fastener Caution in the Preface section. Tighten 2.5 N·m (23 lb in) Rear Side Door Pull Handle Screw T ...

© 2017-2021 Copyright www.crion.site