Chevrolet Cruze manuals

Chevrolet Cruze Repair Manual: Removal Procedure

Warning: Refer to Approved Equipment for Collision Repair Warning in the Preface section.

Warning: Refer to Collision Sectioning Warning in the Preface section.

Warning: Refer to Glass and Sheet Metal Handling Warning in the Preface section.

  1. Disable the SIR System. Refer to SIR   Disabling and Enabling.
  2. Disconnect the negative battery cable. Refer to Battery Negative Cable Disconnection and Connection.
  3. Remove all related panels and components.
  4. Visually inspect the damage. Repair as much of the damage as possible.
  5. Remove the sealers and anti-corrosion materials from the repair area, as necessary. Refer to Anti-Corrosion Treatment and Repair

  1. Locate and mark all the necessary factory welds of the roof panel front bracket right (1).
  2. Drill all factory welds. Note the number and location of welds for installation of the service assembly.

  1. Remove the roof panel front bracket right (1).
  2. Proceed the same way with the roof panel front bracket left.

  1. Create cut lines on the roof front header panel.

  1. Cut the panel where sectioning is to be performed.

  1. Remove the damaged roof front header panel.
Roof Front Header Panel Replacement (MAG-Welding)
Note: According to different corrosion warranties, only the regional mandatory joining methods are allowed. ...

Installation Procedure
Cut the roof front header panel in corresponding locations to fit the remaining original panel. The sectioning joint should be trimmed to allow a gap of one-and-one-half-times the metal th ...

Other materials:

Steering Wheel Inflatable Restraint Module Coil Replacement
Preliminary Procedure Remove the steering column upper trim cover. Refer to Steering Column Upper Trim  Cover Replacement. Remove the steering column lower trim cover. Refer to Steering Column Lower Trim Cover Replacement. Remove the steering wheel. Refer to Steering Wheel Rep ...

Engine Oil Pressure Light
Notice: Lack of proper engine oil maintenance can damage the engine. Driving with the engine oil low can also damage the engine. The repairs would not be covered by the vehicle warranty. Check the oil level as soon as possible. Add oil if required, but if the oil level is within the operating ...

Tail Lamp Replacement
Preliminary Procedures Open and support   the rear compartment lid. Remove the body side trim panel replacement in order to expose the tail lamp pocket nuts. Refer to Body Side Trim Panel Replacement - Left Side. Tail Lamp Bolt (Qty: 2) Caution: Refer to Fastener Caut ...

© 2017-2021 Copyright www.crion.site