Chevrolet Cruze manuals

Chevrolet Cruze Repair Manual: Rear Side Door Upper Hinge and Lower Hinge Replacement

Chevrolet Cruze Repair Manual / Body repair / Bolted Exterior Body Panels and Closures / Rear Side Door Upper Hinge and Lower Hinge Replacement

Preliminary Procedure

Preliminary Procedure

Remove the rear side door. Refer to Rear Side Door Replacement.

  1. Rear Side Door Hinge Bolt (Qty: 4) Caution: Refer to Fastener Caution in the Preface section.

    Tighten 25 N·m (19 lb ft)

  2. Reart Side Door Hinge

Procedure

Adjust rear side door as needed. Refer to Rear Side Door Adjustment.

Front Side Door Upper Hinge and Lower Hinge Replacement
Preliminary Procedure Remove the front wheelhouse liner. Refer to Front Wheelhouse Liner Replacement. Remove the front fender insulator. Refer to Front Fender Insulator Replacement. ...

Hood Adjustment
Hood Caution: Refer to Fastener Caution in the Preface section. Procedure Loosen the hood hinge reinforcement nuts (Qty: 4). Adjust the hood in order to obtain an even gap on both sides be ...

Other materials:

Installation Procedure
Cut the front hinge pillar body in corresponding locations to fit the remaining original panel. The sectioning joint should be trimmed to allow a gap of one-and-one-half-times the metal thickness at the sectioning joint. Create a 50 mm (2 in) backing plate from the unused portion of ...

Hydraulic Clutch
For vehicles with a manual transmission, it is not necessary to regularly check brake/clutch fluid unless there is a leak suspected. Adding fluid will not correct a leak. A fluid loss in this system could indicate a problem. Have the system inspected and repaired. When to Check and What to Us ...

Rear Seats
Either side of the rear seatback can be folded. To fold the rear seatbacks: 1. Place the front seatbacks in the upright position. Notice: Folding a rear seat with the safety belts still fastened may cause damage to the seat or the safety belts. Always unbuckle the safety belts and return them ...

© 2017-2021 Copyright www.crion.site