Chevrolet Cruze manuals

Chevrolet Cruze Repair Manual: Rear Side Door Check Replacement

Preliminary Procedure

Preliminary Procedure

  1. Remove rear side door trim panel. Refer to Rear   Side Door Trim Replacement
  2. Remove the rear side door water deflector. Refer to Rear Side Door Water Deflector Replacement
  1. Rear Side Door Check Bolt

Caution: Refer to Fastener Caution in the Preface section.

Tip Place the door in the full open position.

Tighten 25 N·m (18 lb ft)

  1. Rear Side Door Check Nut

Procedure

Remove the water deflector.

Tighten 9 N·m (79 lb in)

  1. Rear Side Door Check
Hood Primary Latch Release Cable Replacement
Preliminary Procedure Remove hood primary latch release cable handle. Refer to Hood Primary Latch  Release Cable Handle Replacement. Remove the front bumper fascia. Refer to Front Bu ...

Front Side Door Adjustment
Preliminary Procedure Remove the front wheelhouse liner. Refer to Front Wheelhouse Liner Replacement. Front Side Door Caution: Refer to Fastener Caution in the Preface section. Procedure ...

Other materials:

Installation Procedure
Cut the front compartment front rail in corresponding locations to fit the remaining original panel. The sectioning joint should be trimmed to allow a gap of one-and-one-half-times the metal thickness at the sectioning joint. Create a 50 mm (2 in) backing plate from the unused porti ...

Rear Compartment Lid Hinge Torque Rod Replacement
Preliminary Procedure Remove rear compartment lid. Refer to Rear Compartment Lid Replacement. Special Tools BO-125 Torque Rod Lifter For equivalent regional tools, refer to Special Tools. Rear Compartment Lid Hinge Torque Rod - Right Side Tip Only use the special tool to remove and i ...

Adding Equipment to the Airbag-Equipped Vehicle
Adding accessories that change the vehicle's frame, bumper system, height, front end, or side sheet metal, may keep the airbag system from working properly. The operation of the airbag system can also be affected by changing or moving any parts of the front seats, safety belts, the airbag ...

© 2017-2021 Copyright www.crion.site