Chevrolet Cruze manuals

Chevrolet Cruze Repair Manual: Inflatable Restraint Steering Wheel Module Coil Centering

Chevrolet Cruze Repair Manual / Restraints / Inflatable Restraint Steering Wheel Module Coil Centering

Caution: The new SIR coil assembly will be centered. Improper

Caution: The new SIR coil assembly will be centered. Improper alignment of the SIR coil assembly may damage the unit, causing an inflatable restraint malfunction.

  1. Verify the following conditions before centering the supplemental inflatable restraint (SIR) steering  wheel module coil:
  1. Turn the lobe of the clock spring clockwise until the coil ribbon stops. Do not force.
  2. Turn the lobe of the clock spring counterclockwise approximately 3 turns to the Neutral position.

  1. Properly align until the centering window turns yellow (1). This indicates the CENTER position.

Instrument Panel Inflatable Restraint Module Replacement

Warning: Refer to SIR Warning in the Preface section.

Warning: Refer to SIR Warning in the Preface section.

Preliminary Procedure

  1. Disable the SIR system. Refer to  SIR Disabling and Enabling.
  2. Remove the instrument panel assembly. Refer to Instrument Panel Assembly Replacement.

Instrument Panel Inflatable Restraint Module Nut (Qty: 7)

Caution: Refer to Fastener Caution in the Preface section.

Tighten 8 N·m (71 lb in)

Instrument Panel Inflatable Restraint Module Assembly

Tip

Disconnect the electrical connectors.

Steering Wheel Inflatable Restraint Module Coil Replacement
Preliminary Procedure Remove the steering column upper trim cover. Refer to Steering Column Upper Trim  Cover Replacement. Remove the steering column lower trim cover. Refer to Steer ...

Driver or Passenger Seat Side Inflatable Restraint Module Replacement
Warning: Refer to SIR Inflator Module Handling and Storage Warning in the Preface section. Warning: Following the deployment of a side impact air bag, inspect the following parts for damage ...

Other materials:

Lower Anchors and Tethers for Children (LATCH System)
The LATCH system secures a child restraint during driving or in a crash. LATCH attachments on the child restraint are used to attach the child restraint to the anchors in the vehicle. This system is designed to make installation of a child restraint easier. Make sure that a LATCH-compatible ch ...

Charging System Light
The charging system light comes on briefly when the ignition is turned on, but the engine is not running, as a check to show the light is working. The light turns off when the engine is started. If it does not, have the vehicle serviced by your dealer. If the light stays on, or comes on whil ...

Roof Console Replacement
Dome Lamp Bezel Roof Console Screw (Qty: 2) Caution: Refer to Fastener Caution in the Preface section. Tighten 2.5 N·m (22 lb in) Roof Console Assembly Procedure Disconnect  the electrical connectors. When replacing the driver information display bezel, remove the dri ...

© 2017-2021 Copyright www.crion.site