Chevrolet Cruze manuals

Chevrolet Cruze Repair Manual: Inflatable Restraint Side Impact Sensor Replacement

Chevrolet Cruze Repair Manual / Restraints / Inflatable Restraint Side Impact Sensor Replacement

Warning: Refer to SIR Warning in the Preface section.

Warning: Refer to SIR Warning in the Preface section.

Warning: Refer to SIR Inflator Module Handling and Storage Warning in the Preface section.

Warning: Following the deployment of a side impact air bag, inspect the following parts for damage. Replace these parts if necessary:

Failure to do so may cause future personal injury.

Preliminary Procedure

  1. Disable the SIR system. Refer   to SIR Disabling and Enabling
  2. Remove center pillar lower garnish molding. Refer to Center Pillar Lower Garnish Molding Replacement

Inflatable Restraint Side Impact Sensor Screw

Caution: Refer to Fastener Caution in the Preface section.

Tighten 7.5 N·m (66 lb in)

Inflatable Restraint Side Impact Sensor Assembly

Procedure

  1. Disconnect electrical connector.
  2. Loosen the bolts and slide the sensor out of the keyhole slots.

Tip

The bolt is integral to the sensor assembly, DO NOT remove separately.

Inflatable Restraint Sensing and Diagnostic Module Replacement

Preliminary Procedure

Preliminary Procedure

  1. Disable the supplemental inflatable restraint (SIR) system. Refer to SIR   Disabling and Enabling.
  2. Remove the instrument panel lower trim panel. Refer to Instrument Panel Lower Trim Panel Replacement - Left Side and Instrument Panel Lower Trim Panel Replacement - Right Side
  3. Disconnect the electrical connector.

Inflatable Restraint Sensing and Diagnostic Module Nut (Qty: 3)

Caution: Refer to Fastener Caution in the Preface section.

Tighten 10 N·m(89 lb in)

Inflatable Restraint Sensing and Diagnostic Module Assembly

Tip

If installing a replacement module, program the module. Refer to Control Module References

Front End Inflatable Restraint Discriminating Sensor Replacement
Warning: Refer to SIR Warning in the Preface section. Warning: Following the deployment of a side impact air bag, inspect the following parts for damage. Replace these parts if necessary: ...

Steering Wheel Inflatable Restraint Module Replacement
Removal Procedure Warning: When carrying a live inflator module, make sure the bag opening is pointed away from you. This minimizes the chance of injury in the case of an accidental deployment. Ne ...

Other materials:

Front End Upper Tie Bar Replacement
Preliminary Procedure Remove the front bumper fascia. Refer to Front  Bumper Fascia Replacement Remove the radiator support bracket. Refer to Radiator Support Bracket Replacement Remove the radiator grille reinforcement support. Refer to Radiator Grille Reinforcement Suppor ...

Passenger Airbag Status Indicator
The vehicle has a passenger sensing system. The instrument panel has a passenger airbag status indicator. United States Canada When the vehicle is started, the passenger airbag status indicator will light ON and OFF, or the symbol for on and off, for several seconds as a system check. If ...

Where Are the Airbags?
The driver frontal airbag is in the center of the steering wheel. The front outboard passenger frontal airbag is in the passenger side instrument panel. The driver knee airbag is below the steering column. The front outboard passenger knee airbag is below the glove box. Driver Side Show ...

© 2017-2021 Copyright www.crion.site