Chevrolet Cruze Repair Manual: Hood Adjustment
Hood
Caution: Refer to Fastener Caution in the Preface section.
Procedure
- Loosen the hood hinge reinforcement nuts (Qty: 4).
- Adjust the hood in order to obtain an even gap on both sides between the hood and the fenders, the headlamps and the front bumper fascia and so that the hood is flush with both fenders on the front edge, the front bumper fascia and the headlamps.
Adjustment
- Hood to front fender (a) 3.0 mm ± 0.75 mm (0.12 in ± 0.03 in)
- Hood to headlamp (b) 3.0 mm ± 1.0 mm (0.12 in ± 0.04 in)
- Hood to headlamp (c) 4.5 mm ± 1.5 mm (0.18 in ± 0.06 in)
- Hood to front bumper fascia (d) 4.0 mm ± 1.0 mm (0.16 in ± 0.04 in)
Tighten 26 N·m (20 lb ft)
Rear Side Door Upper Hinge and Lower Hinge Replacement
Preliminary Procedure
Remove the rear side door. Refer to Rear Side Door Replacement.
Rear Side Door Hinge Bolt (Qty: 4)
Caution: Refer to Fastener Caution in the Preface section.
Tight ...
Hood Replacement
Warning: When a hood hold open device is being removed or installed,
provide alternate support to avoid the possibility of
damage to the vehicle or personal injury.
Preliminary Procedure
Remo ...
Other materials:
Charging System Light
The charging system light comes on briefly when the ignition is turned on, but
the engine is not running, as a check to show the light is working.
The light turns off when the engine is started. If it does not, have the vehicle
serviced by your dealer.
If the light stays on, or comes on whil ...
Installation Procedure
Align the rear compartment floor panel.
Drill 4 mm (3/16 in) for rivets along the edges of the rear compartment
floor were you cant apply a resistance spot welder.
Clean and prepare the attaching surfaces for
spot welding and riveting.
Apply structural adhesive to all a ...
Securing Child Restraints (Front Passenger Seat)
This vehicle has airbags. A rear seat is a safer place to secure a forward-facing
child restraint.
In addition, the vehicle has a passenger sensing system which is designed to
turn off the right front passenger frontal airbag and passenger knee airbag under
certain conditions.
A label on the ...