Chevrolet Cruze manuals

Chevrolet Cruze Repair Manual: Front Side Door Upper Hinge and Lower Hinge Replacement

Chevrolet Cruze Repair Manual / Body repair / Bolted Exterior Body Panels and Closures / Front Side Door Upper Hinge and Lower Hinge Replacement

Preliminary Procedure

Preliminary Procedure

  1. Remove the front wheelhouse liner. Refer to Front Wheelhouse Liner Replacement.
  2. Remove the front fender insulator. Refer to Front Fender Insulator Replacement.
  3. Remove the front side door. Refer to Front Side Door Replacement.
  1. Front Side Door Hinge Bolt (Qty: 4) Caution: Refer to Fastener Caution in the Preface section.

    Tighten 25 N·m (19 lb ft)

  2. Front Side Door Hinge

Procedure

Adjust front side door as needed. Refer to Front Side Door Adjustment.

Hood Hinge Replacement

Preliminary Procedure

Preliminary Procedure

  1. Remove the hood.  Refer to Hood Replacement.
  2. Remove the front fender. Refer to Front Fender Replacement.
  1. Hood Hinge Bolt (Qty: 2) Caution: Refer to Fastener Caution in the Preface section.

    Tighten 26 N·m (19 lb ft)

  2. Hood Hinge

Rear Compartment Lid Rear Hinge Replacement

Preliminary Procedure

Preliminary Procedure

  1. Remove the rear compartment lid. Refer to Rear   Compartment Lid Replacement
  2. Remove the rear window panel trim. Refer to Rear Window Panel Trim Replacement
  1. Rear Compartment Lid Rear Hinge Bolt (Qty: 2) Caution: Refer to Fastener Caution in the Preface section.

    Tighten 9 N·m (80 lb in)

  2. Rear Compartment Lid Rear Hinge

Procedure

Adjust rear compartment lid as needed. Refer to Rear Compartment Lid Adjustment

Hood Primary Latch Release Cable Handle Replacement
Preliminary Procedure Remove the front side door sill trim plate. Refer to Front Side Door Sill Trim Plate Replacement. Hood Primary Latch Release Cable Handle Procedure Pull down the hoo ...

Rear Side Door Upper Hinge and Lower Hinge Replacement
Preliminary Procedure Remove the rear side door. Refer to Rear Side Door Replacement. Rear Side Door Hinge Bolt (Qty: 4) Caution: Refer to Fastener Caution in the Preface section. Tight ...

Other materials:

Floor Air Outlet Replacement
Removal Procedure Remove the instrument panel assembly. Refer to Instrument Panel  Assembly Replacement. Remove the instrument panel wiring harness (2) from the instrument panel tie bar (1). Disconnect the electrical connectors. Remove the instrument panel tie bar ...

Fuel Tank Filler Pipe Housing Replacement
Preliminary Procedure Remove rear wheelhouse panel liner. Refer to Rear Wheelhouse Panel Liner Replacement. Remove fuel tank filler door. Refer to Fuel Tank Filler Door Replacement. Fuel Tank Filler Door Lock Actuator Procedure Disconnect electrical connector. Fuel Tank ...

Tire Messages
SERVICE TIRE MONITOR SYSTEM This message displays if there is a problem with the Tire Pressure Monitor System (TPMS). TIRE LEARNING ACTIVE This message displays when the system is learning new tires. TIRE PRESSURE LOW ADD AIR TO TIRE On vehicles with the Tire Pressure Monitor System (TPMS), t ...

© 2017-2021 Copyright www.crion.site