Chevrolet Cruze manuals

Chevrolet Cruze Repair Manual: Driver or Passenger Seat Retractor Side Belt Replacement

Chevrolet Cruze Repair Manual / Restraints / Driver or Passenger Seat Retractor Side Belt Replacement

Warning: Refer to SIR Warning in the Preface section.

Warning: Refer to SIR Warning in the Preface section.

Warning: In order to prevent accidental deployment and the risk of personal injury, do not dispose of an undeployed inflatable restraint seat belt pretensioner as normal shop waste. Undeployed seat belt pretensioners contain substances that could cause severe illness or personal injury if their sealed containers are damaged during disposal. Use the following deployment procedures to safely dispose of an undeployed seat belt pretensioner. Failure to observe the following disposal methods may be a violation of federal, state, or local laws.

Warning: Refer to SIR Seatbelt Pretensioner Handling Warning in the Preface section.

Preliminary Procedure

  1. Remove the Center Pillar Upper Garnish Molding. Refer to Center Pillar Upper Garnish Molding Replacement.
  2. Remove the Front Seat Outer Recliner Upper Finish Cover. Refer to Front Seat Outer Recliner Upper Finish Cover Replacement.
  1. Front Seat Belt Anchor Plate Bolt

Caution: Refer to Fastener Caution in the Preface section.

Tighten 9 N·m (80 lb in)

  1. Front Seat Belt Retractor D Ring Bolt

Tighten 45 N·m (33 lb ft)

  1. Front Seat Shoulder Belt Guide Retainer
  2. Front Seat Shoulder Belt Retractor Assembly Bolt

Tighten 45 N·m (33 lb ft)

  1. Front Seat Retractor Side Belt Assembly
Roof Side Rail Inflatable Restraint Module Replacement
Warning: In order to prevent SIR deployment, personal injury, or unnecessary SIR system repairs, do not strike the door or the door pillar in the area of the side impact sensor (SIS). Turn OFF ...

Repairs and Inspections Required After a Collision
...

Other materials:

Inflatable Restraint Module Handling and Scrapping
Special Tools EL-38826 SIR Deployment Harness EL-39401-B SIR Deployment Fixture For equivalent regional tools, refer to Special Tools. Live and Undeployed Inflator Module Warning: Refer to SIR Inflator Module Handling and Storage Warning in the Preface section. Take special care when h ...

Lifting and Jacking the Vehicle
Note: The use of a LOW PROFILE LIFT ARMS SYSTEM may be required to avoid unwanted contact with the vehicle's body and structure depending on lifting equipment used. Refer to the manufacture's recommendation for their applications of low profile lift arms system for their lifting equipment. ...

Engine Oil Pressure Light
Notice: Lack of proper engine oil maintenance can damage the engine. Driving with the engine oil low can also damage the engine. The repairs would not be covered by the vehicle warranty. Check the oil level as soon as possible. Add oil if required, but if the oil level is within the operating ...

© 2017-2021 Copyright www.crion.site