Chevrolet Cruze manuals

Chevrolet Cruze Repair Manual: Air Conditioning Compressor Replacement (1.6L LDE, LXV, and 1.8L 2H0)

Chevrolet Cruze Repair Manual / HVAC System / Air Conditioning Compressor Replacement (1.6L LDE, LXV, and 1.8L 2H0)

Preliminary Procedures

Preliminary Procedures

  1. Recover the refrigerant. Refer to Refrigerant Rec  . overy and Recharging.
  2. Remove drive belt. Refer to Drive Belt Replacement.
  3. Raise and support the vehicle. Refer to Lifting and Jacking the Vehicle.
  4. Disconnect the A/C compressor electrical connector
  5. Remove compressor hose assembly. Refer to Air Conditioning Compressor and Condenser Hose Replacement.
  1. A/C Compressor Bolt (Qty: 3)

Caution: Refer to Fastener Caution in the Preface section.

Tighten 22 N·m (16 lbf ft)

  1. A/C Compressor Assembly

Procedure

  1. Use a low viscosity, poly-alkylene glycol (PAG) oil. Use of the incorrect oil can result in compressor failure.
  2. When replacing the A/C compressor, balance the compressor oil. Refer to Air Conditioning Compressor Oil Balancing
  3. Using GE 39400-A detector leak test A/C compressor fittings.

Special Tools

GE 39400-A Electronic Halogen Leak Detector

For equivalent regional tools, refer to Special Tools.

Refrigerant Recovery and Recharging
Special Tools GE-45037 A/C Oil Injector For equivalent regional tools, refer to Special Tools. Refrigerant Recovery and Recharging Warning: To prevent personal injury, avoid breathing A/C Refriger ...

Air Conditioning Compressor Replacement (1.6L LXT)
Preliminary Procedures Recover the refrigerant. Refer to Refrigerant Rec  overy and Recharging. Remove drive belt. Refer to Generator and Air Conditioning Compressor and Power Ste ...

Other materials:

Installation Procedure
Cut the roof front header panel in corresponding locations to fit the remaining original panel. The sectioning joint should be trimmed to allow a gap of one-and-one-half-times the metal thickness at the sectioning joint. Create a 50 mm (2 in) backing plate from the unused portion of ...

Headlining Trim Panel Replacement (With Sunroof)
Warning: Do not attempt to repair or alter the head impact energy-absorbing material glued to the headliner or to the garnish trims. If the material is damaged, replace the headliner and/or the garnish trim. Failure to do so could result in personal injury. Caution: If a vehicle is equip ...

Exterior Lighting Systems Description and Operation
Exterior Lamps The exterior lighting system consists of the following lamps if equipped: Headlamps Daytime Running Lamps (DRL) Front fog lamps Rear fog lamps Park, tail and license lamps Turn signal lamps Hazard warning lamps Repeater lamps Stop lamps Backup lamps Low Beam ...

© 2017-2021 Copyright www.crion.site